中英双语垃圾电站可行性报告DOC41页.docx
《中英双语垃圾电站可行性报告DOC41页.docx》由会员分享,可在线阅读,更多相关《中英双语垃圾电站可行性报告DOC41页.docx(35页珍藏版)》请在冰豆网上搜索。
![中英双语垃圾电站可行性报告DOC41页.docx](https://file1.bdocx.com/fileroot1/2022-10/9/4d081f71-7661-4bf0-9ed0-2f2acf7cfd23/4d081f71-7661-4bf0-9ed0-2f2acf7cfd231.gif)
中英双语垃圾电站可行性报告DOC41页
城市垃圾焚烧发电项目
Municipalsolid wasteincinerationpowergenerationproject
方案
江苏国际经济技术合作公司
2017/2/20
ﻬ
前言Preface
随着城市化进程的加快,垃圾污染日益严重。
对垃圾处理不当,会造成严重的大气、水和土壤污染,并将占用大量土地,从而制约城市的生存与发展。
如何解决垃圾问题,已引起全社会的高度重视。
城市垃圾是居民生活产生的废弃物,但从另一个角度来说,垃圾也不是百无一用的废物,如果科学地加以利用,它也是地球上可以不断增长的可再生资源。
面对垃圾泛滥的现状,全球专家已经不再仅仅着眼于控制和销毁的被动防守,而是主动将垃圾和能源这一废一宝紧密联系起来,例如:
利用垃圾发电来解决能源问题。
With theaccelerationoftheurbanizationprocess,thewastepollutionis becomingmoreand moreserious.Improperdisposalofwaste willcauseseriousair, water andsoil pollution, andwilloccupyalotofland,thereby restricting the survivalanddevelopment ofthecity. How tosolvethegarbageproblemhasarousedgreatattentionofthewholesociety.
Cityresidentslivinggarbageis a waste, butfromanother perspective,thegarbageisnotgood for nothingwaste,ifscienceisto use,itisalsotheearthcouldbe growingrenewableresources.Facingthe situationofgarbageflooding,globalexpertshavenotonlyfocustocontrol and destroythepassivedefense,butthis initiativewillwasteenergyandwaste aprecioustogether, forexample:
theuse of garbagepower tosolve the energyproblem.
ﻩ
一、建设规模Constructionscale
一个总人口130万,中心城区人口40万,农村人口90万的城市,日产垃圾约650吨/日,利用这些生活垃圾建设垃圾焚烧发电厂,建设2台日处理垃圾400吨的焚烧炉配置2套9MW的汽轮发电机组。
其主机技术条件如下:
Atotal populationof1million300thousand,thecenter ofthe urbanpopulationof 400thousandrural population,900thousandof the city,Nissan garbage about650 tons/day, the useofthesewasteconstructionwaste incinerationpowerplant, turbinegenerator incineratorconfiguration of 400tonsofconstructionwaste disposal,2 sets of 2sets of9MW.Themaintechnicalconditionsareasfollows:
1、焚烧炉主要技术规范Maintechnicalspecificationforincinerator
焚烧炉台数:
Number ofincineratorﻩ2台套
焚烧炉形式:
Incineratorformﻩ机械炉排炉stokerfired grate
炉排数量:
FireGratequantityﻩ2套
每套炉排处理垃圾的能力:
16.7t/h
400t/d
Theabilityofeachgratetodeal withgarbage
后燃烧室的最低温度(二次风后):
850℃
The lowesttemperature of the combustionchamber(twostroke)
烟气在超过850℃范围内的滞留时间:
≥2秒
Residence timeoffluegasinexcess of850DEG C
超负荷连续运行时间:
ﻩ≥负荷连续运行时间:
二次
Overloadcontinuousrunning time Continuousrunning time:
twice
负荷范围:
60~110%
Load range
焚烧垃圾的设计低位热值:
1530kcal/kg
Low calorific value ofincineration waste
可焚烧垃圾的上限大低位热值:
2050kcal/kg
Upperand lowercalorific valueofincinerationwaste
可焚烧垃圾的下限低位热值:
ﻩ1000kcal/kg
Lower limitcalorificvalueof burnable waste
炉渣热灼减率:
ﻩ≤渣%
Slag burningrate
每座焚烧炉辅助燃烧器:
ﻩ2台
Auxiliaryburnerforeachincinerator
辅助燃料:
#0轻柴油
Auxiliaryfuel #0light dieseloil
渗沥液回喷系统:
具备
Leachateinjectionsystem Have
垃圾给料系统数量:
ﻩ2套
Quantityofrefuse feedingsystem
每套给料系统的给料能力(MCR工况下):
25t/h
Feeding capacityof eachfeeding system (MCR)
垃圾料斗储存量满足的连续运行时间:
ﻩ1h
Continuousrunningtimeofgarbage hopperstorage
2、余热锅炉主要技术规范Maintechnicalspecification forwasteheatboiler
型式:
ﻩ自然循环卧式水管锅炉
Type Natural circulationhorizontalwatertubeboiler
数量:
2套
Quantity
MCR时的蒸发量:
57t/h
Evaporation capacityatMCR
末级过热蒸汽压力:
ﻩ4.0MPa(a)
Finalsteampressure
末级过热蒸汽温度:
ﻩ400℃
Finalsuperheatedsteamtemperature
锅炉给水压力:
4.9MPa(a)
Boilerfeedpressure
锅炉给水温度:
130℃
Boilerfeedwatertemperature
汽包压力:
ﻩ4.7MPa(a)
Drumpressure
烟气流量:
最大96000Nm3/h (110%MCR)
Gasflow
余热锅炉进口烟气温度:
850~1000℃
Exhaustgastemperature
余热锅炉锅炉省煤器出口烟气温度:
ﻩ165~195℃
Exhaustgastemperatureofboilereconomizerofwaste heat boiler
余热锅炉热效率:
ﻩ≥82 %(MCR)。
Thermalefficiency ofwasteheatboiler
3、汽轮机主要技术规范Maintechnicalspecificationforsteam turbine
数量:
2台
Quantity
型号:
ﻩQF9-2
Type
额定功率:
ﻩ9000kW
Powerratings
最大功率:
9900kW
Maximumpower
正常功率:
ﻩ7600kW
Normaloutput
型式:
中压、单缸、凝汽式
Type Medium pressure,singlecylinder, condensingtype
进汽压力:
ﻩ3.8MPa
Inlet steampressure
进汽温度:
ﻩ395℃
Inlet steamtemperature
额定进气量:
ﻩ43.9t/h
Ratedair input
最大进气量:
48t/h
Maximumairinput
正常进气量:
ﻩ37t/h
Normalair input
4、汽轮发电机主要技术规范Maintechnicalspecificationforturbo-dynamo
数量ﻩ2台
Quatity
型号QF-9-2
Type
额定功率9MW
Powerratings
电压ﻩ10.5kV
Voltage
额定转速ﻩ3000r/min
Ratedspeed
功率因数0.8
Powerfactor
频率变化范围ﻩ48.5~50.5Hz
Frequencyvariationrange
冷却方式空气冷却
Coolingmethod
发电机效率>97%
Generatorefficiency
二、处理垃圾情况Garbagedisposal
1、设计垃圾低位热值的确定Determination oflowcalorificvalueof waste
城市垃圾和常规燃料煤炭、石油、天然气不同,具有非均质性和多变性,且各区域、各个季节垃圾变化是很大的,这给垃圾焚烧带来一定困难。
能对垃圾进行焚烧发电处理,必须具有一定条件:
垃圾要具有一定的发热值,当垃圾中低位发热值≤3350kJ/kg(800kcal/kg)时,焚烧需助燃,掺煤或烧油助燃。
一般认为,垃圾低位发热值>5000kJ/kg(1200kcal/kg)燃烧效果较好。
一般城市生活垃圾低位发热值在3350~8374kJ/kg(800-2000kcal/kg)范围,垃圾中含水量≤50%。
Urbanwasteandconventionalfuelcoal,oil, naturalgasisdifferent, withheterogeneityandvariability,andinvarious regions,seasonalchangesingarbageisverylarge,which bringssomedifficulties towasteincineration.Canthe garbageincinerationpowergeneration,musthavecertainconditions:
refusetohave acertain calorificvalue, whenthe gar