设备保养维护管理办法.docx
《设备保养维护管理办法.docx》由会员分享,可在线阅读,更多相关《设备保养维护管理办法.docx(35页珍藏版)》请在冰豆网上搜索。
设备保养维护管理办法
WORKINGINSTRUCTION
工作指導書
DOCUMENTNO.:
文件編號
WI-PFAC-015
EFFECTIVEDATE:
生效日期
10/01/2003
VERSION:
版次
1
PAGE:
頁次
1OF16
SUBJECT:
主題
EquipmentMaintenanceManagement
設備保養維護管理辦法
ORIGINATOR:
起草人
朱吉偉
10/01/2003
APPROVEDBY:
核准人
DOC.CHANGENO.VERSIONEFFECTIVEDATEMODIFYDESCRIPTION
DCN版次新版生效日期內容(變更敘述)-----------------------------------------------------------------------------
0310016110/01/2003(Revisionfirst)初版
ReleaseDept.
分發單位
ADM
管理部
Signature
簽收
PAGENO.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
VERSION
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
DATE
SUBJECT:
主題
DOC.NO.
WI-PFAC-015
EquipmentMaintenanceManagement
設備保養維護管理辦法
PAGENO.
2OF16
VERSION
1
DATE
10/01/2003
1.0purpose目的
inordertomaketheequipmentbeoperatedcorrectlyandmaintainedreasonablytokeeptheequipmentrunninginanormalwayandreducetheaccident為了使設備有正確的操作方法及合理的保養與維護,以確保設備保持正常狀態,減少發生意外事故.
2.0scope適用範圍
alltheequipmentinthefactory(excepttheSMTmachine)
本廠內設備(除SMT機器外).
3.0responsibility責任
3.1theelectriciansoftheADMwillbeinchargeofthemaintenanceandrepair(excepttheSMTmachine)
管理部電工負責保養及維修(除SMT機器外).
3.2thepeopleatpresentofeachunitmustexecuteandmaintainbytherequirement各單位現場人員必須按要求去執行并加以維護.
4.0content內容
4.1electricapparatus電气設備:
4.1.1theelectricianoftheADMwillbeinchargeofthecheckandmeasureindate(formone)
定期檢查測量由管理部電工負責(記錄表見附件一).
4.1.2checkandmeasuretheelectricapparatusandfillthe“electricapparatusseasoncheckform”
每季度檢查測量電气設備並填寫<<電气設備安全每季檢查表>>
SUBJECT:
主題
DOC.NO.
WI-PFAC-015
EquipmentMaintenanceManagement
設備保養維護管理辦法
PAGENO.
3OF16
VERSION
1
DATE
10/01/2003
4.1.3maintainthegeneratorbythe“generatorairpressuremachineoperationandrepairmanagement”
按照<<發電机空壓机操作維修管理辦法>>對發電机空壓机實施保養.
4.14thepeopleatpresentshouldnotifytheelectricianoftheADMiffindtheabnormality(creepage,nopowerorburnttaste,etc.)inthecourseofoperation.
現場人員在使用過程中若發現有異常(如漏電,無電或焦气味等),要立即通知管理
部電工維修.
4.15Iftheuseunitneedstochangethejointorincreasetheplug,andsoon,theelectricianofADMwillfixtogether.Itisforbiddentopushandjointhepowersupplywithoutpermission.
使用單位若需改接或增加插座等,由管理部電工統一安裝,嚴禁自行私拉、亂接電源.
4.16theelectricianshouldoperatebytheinternationalstandardwhenrationthepower.
管理部電工在配電時要按照國際標準化作業.
4.1.7inthecourseofusingtheelectricity,itshouldbepaidattentionifthepressureusedisthesamewiththeonethatdemandedbytheapparatus.(suchas110Vand220V).
用電單位在使用過程中要注意所使用電壓要與設備所需電壓相符(如110V和
220V).
4.2gassupplysystem:
供氣系統:
4.2.1air-pressuremachine,dry-machine,thepipewillbecheckedandmaintainedbytheelectricianindate.
SUBJECT:
主題
DOC.NO.
WI-PFAC-015
EquipmentMaintenanceManagement
設備保養維護管理辦法
PAGENO.
4OF16
VERSION
1
DATE
10/01/2003
空壓機,干燥機,管路由電工定期檢查保養.
4.2.2ifthepeopleatpresentshouldnotifytheADMrightawaywhenhearthegasleak,ortheairpressureisnotenough(lessthan5Kg/cm2).
現場人員若聽到有漏气或气壓不足(低于5Kg/cm2)要立即通知管理部電工處理.
4.2.3thealarmofthelowairpressureis6kg/cm2,itisforbiddentochangetheresultforthenone-electricianwithoutpermission.thepowersupplyshouldbekeptnormalandtheswitchshouldbekeptshut,thepeopleatpresentshouldnotifytheelectricianoftheADMrightawaywhenhearthealarm.(airpressurerecordformtwo)
低气壓報警器設定值為6kg/cm2,嚴禁非電工人員隋意改動設定值,并要保持電源常通和開關常閉,現場人員聽到警鈴響時,要立即通知管理部電工(气壓記錄表見附件二).
4.3watersupplysystem供水系統:
4.3.1thesluicepoolandthepressure-increasedpumpwillbespot-inspectedbytheelectricianandmaintainedindate,thehotandcoolwatershouldbesuppliedtotheworkshopduringthe24hours.(formthree:
drinkingmachinecheckandmaintenancerecord)
蓄水池和增壓泵由電工不定時巡視,定期性保養,車間內保持24小時供應熱水和冰水(飲水機檢查記錄表見附件三)
4.3.2thepeopleofeachunitshouldnotifytheelectricianrightawayto
repairiffindaleak,etc.
各單位人員若發現有漏水等,要立即通知電工進行維修處理.
SUBJECT:
主題
DOC.NO.
WI-PFAC-015
EquipmentMaintenanceManagement
設備保養維護管理辦法
PAGENO.
5OF16
VERSION
1
DATE
10/01/2003
4.3.3Theusershouldusethetapandswitchcorrectlyandsavewater.
使用者要正確使用水襲頭和閘閥并要節約用水.
4.3.4Electricianscheckandrectifydrinkingmachinewiretoavoidhurtingpeople
電工每日檢查整理飲水機線材防止線材凌亂造成人員傷害。
4.3.5Electricianscheckthestorageboxofthedrinkingmachinetoavoidwateraleaktohurtpeople.
電工每日檢查飲水機儲水箱是否漏水防止造成人員傷害。
4.3.6Washthefiltrationcoreofthedrinkingmachine,andchangeiteverytwoweeksandfilltheapparatusmaintenancerepairrecord.
每周清洗飲水機濾芯,每兩更換飲水機濾芯並填寫設備維修保養記錄表。
4.3.7Thesluicebucketofthedrinkingmachineshouldbewashedoncethreemonths純水機蓄水桶每3個月清洗一次
4.4airconditioner空調設備:
4.4.1Theairconditionerwillbemaintained,repairedandchecked.(attachmentfour)
空調由廠務人員保養、維修檢查<見附件四>.
4.4.2Theinternaltemperatureshouldbekeptbetween20---30centigrade,excepttheSMT,electronichouse,importanthouse,thecentralairconditionersinotherscanbeopenedonlywhenthetemperatureisover27centigrade.Thenone-operationpeopleareforbiddentooperatethe
airconditioner.
室內溫度一般保持在20----30℃之間,除SMT、電子倉、貴重倉外,其余室溫高于
SUBJECT:
主題
DOC.NO.
WI-PFAC-015
EquipmentMaintenanceManagement
設備保養維護管理辦法
PAGENO.
6OF16
VERSION
1
DATE
10/01/2003
270C時才開中央空調,非操作人員嚴禁操作空調.
4.4.3ExcepttheSMT,electronichouse,importanthouse,thecentralairconditionercanrunningbetweenAM7:
30----PM17:
00,intheweekend,thecirconditionercanbeopenedaccordingtotheovertimepeople.(commonlyoverfivepeopleandthetemperatureisover27centigrade)
除SMT、電子倉、貴重倉外,中央空調工作時間為AM7:
30----PM17:
00,周六、周日根据加班人員數量适當開啟空調.(一般要在5人加班以上且室溫超過270C才可開空調).
4.5ESDlineESD線路:
4.5.1theESDlinewillbespanned,maintained,andcheckedbytheelectricianoftheADMalltogether.
ESD線路由管理部電工統一架設、保養、維修.
4.5.2thepeopleatpresentmustcheckthestatichand-circle,iffindabnormality,shouldnotifytheelectricianoftheADMtomaintainorchange.Itisforbiddentodisconnectandmeet.Whenuseit,itisshouldbepreventedtomakethebarespacetouchtheequipment.
現場人員所戴靜電手環上班之前必須測試其好壞,若有羿常要通知管理部電工維修或更換,嚴禁自行拆下和亂接,在使用中要預防裸露處與設備靠接.
4.5.3thestaticmonitor(MK_8406)willrecordthedataaboutthelineittested
in24hours,thecheckershouldcheckthedataofeachdaytoseeifthemonitorshowsOKorFAIL(thestandardresultisbetweenonetoonehundredΩ),iffindabnormality,notifytheelectricianrightawaytorepair.
SUBJECT:
主題
DOC.NO.
WI-PFAC-015
EquipmentMaintenanceManagement
設備保養維護管理辦法
PAGENO.
7OF16
VERSION
1
DATE
10/01/2003
靜電監視器會24小時記錄所測線路數據,負責檢查人員要認真檢查每天所測數據是顯示OK或FALL(標準值在14.6productionlineequipment生產線設備
4.6.1Theelectricianisinchargeoftheproductiontineandattachedeguipment.
生產線及附屬設施、設備由電工負責實施保養.
4.6.2Accordingtotheproductionline‘srule,theelectricianprotectandmaintaintheequipment
按照<<生產線設備操作與保養管理辦法>>實施操作保養.
4.6.3.Maintaintheequipmentinadvanceandprolongitslife
設備零件壽命到期提前預防保養.
4.6.4checkthepowerequipmentbeforeproducing,andconfirmingalltheequipmentsarenormal.
每日開線前按照<<電(動)力机械設備檢查表>>實施檢查,确認無異常才能開線
5.0附件:
5.1attachmentone:
electricityarkcheckandmaintenancerecord附件一:
電櫃檢查維護記錄表.
5.2Attachmenttwo:
SMTairpressurerecord
附件二:
SMT氣壓記錄表.
5.3attachmentthree:
drinkingmachinecheckandmaintenancerecord附件三:
飲水機檢查保養記錄表.
SUBJECT:
主題
DOC.NO.
WI-PFAC-015
EquipmentMaintenanceManagement
設備保養維護管理辦法
PAGENO.
8OF16
VERSION
1
DATE
10/01/2003
5.4Attachmentfour:
airconditionercheckrecord
附件四:
空調機檢查記錄表.
5.5attachmentfive:
equipmentmaintenancerecord
附件五:
設備保養維修記錄表.
5.6Attachmentsix:
electriciandutyrecord附件六:
電工值班記錄表.
5.7Attachmentseven:
quarterlychecktheelectricalequipmentform
附件七:
電气設備安全每季檢查表
5.8attachmenteight:
powermechanicalequipmentscheckingform
附件八:
電(動)力机械設備檢查表.
SUBJECT:
主題
DOC.NO.
WI-PFAC-015
EquipmentMaintenanceManagement
設備保養維護管理辦法
PAGENO.
9OF16
VERSION
1
DATE
10/01/2003
attachmentone:
electricityarkcheckandmaintenancerecord附件一:
電櫃檢查維護記錄表
electricityarkcheckmaintenancerecord電柜檢查維護記錄表
code編號:
item項目
date日期
mperemeter電流表
voltagemeter電壓表
indicationlight指示燈
arkearth柜體接地
electricityleakprotection漏電保護
loadbalance負載平衡
sound聲音
smell气味
temperature溫度
nutlooseandtight螺絲松緊
insulatingdegree絕緣度
checker檢查人
remark備注
WI-PFAC-015-FORM01-A
remark注:
checkifnormal,write"V".1檢查正常劃"V".
checkonceeveryhalfamonth2.每半月檢查一次.
SUBJECT:
主題
DOC.NO.
WI-PFAC-015
EquipmentMaintenanceManagement
設備保養維護管理辦法
PAGENO.
10OF16
VERSION
1
DATE
10/01/2003
Attachmenttwo:
SMTairpressurerecord附件二:
SMT氣壓記錄表
SMTairpressurerecordSMT气壓記錄表
__Y年__Munit單位:
KG/CM2
Date
日期
work
time班別
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
morningwork早班