XPS板外墙外保温面砖饰面系统热镀锌钢丝网01施工方案.docx
《XPS板外墙外保温面砖饰面系统热镀锌钢丝网01施工方案.docx》由会员分享,可在线阅读,更多相关《XPS板外墙外保温面砖饰面系统热镀锌钢丝网01施工方案.docx(16页珍藏版)》请在冰豆网上搜索。
XPS板外墙外保温面砖饰面系统热镀锌钢丝网01施工方案
XPS板外墙外保温面砖饰面系统
(热镀锌钢丝网)施工方案
原材料要求
1、进入工地的原材料必须有出厂合格证和检测报告。
2、XPS板摆放平整,防止雨淋及阳光曝晒。
3、XPS板粘接砂浆和抹面砂浆必须有出厂日期,凡有结块现象或出厂日期超过3个月的必须根据化验结果确定如何使用。
4、热镀锌钢丝网必须放在干燥处,地面必须平整,摆放宜立放平整,避免相互交错摆放。
一、基层处理
1、做XPS外墙保温系统的墙面应进行墙体抹灰,找平基层,墙面平整度用2M靠尺检测,其平整度≤3MM,阴、阳角方正。
局部不平整超限度部位用1:
2水泥砂浆找平。
2、基层表面应光滑、坚固、干燥、无污染或其它有害材料。
3、墙外的消防梯、水落管、防盗窗预埋件或其它预埋件、进口管线或其它预留洞口,应按设计图纸或施工验收规范要求提前施工。
二、施工要求
1、施工温度不应低于5度,而且施工完成后24小时内气温高于5度。
夏季高温时,不宜在强光下施工。
2、5级风以上或雨天禁止作业。
3、抹找平层前,抹灰部位根据情况提前半个小时浇水。
4、找平层用1:
3水泥砂浆。
5、窗口、水平角及垂直角要挂线施工。
三、XPS板外墙保温系统的施工
1、施工程序
基层检查或处理→工具准备→阴阳角、门窗膀挂线→基层墙体湿润→配制聚合物粘结砂浆,挑选XPS板→粘贴XPS保温板→XPS板塞缝、打磨、找平墙面→配置聚合物抹面砂浆→XPS板抹聚合物抹面砂浆,门窗洞口处理,翻包部位粘贴玻纤网→铺设镀锌钢丝网及安装尼龙锚固件→抹聚合物抹面砂浆→找平修补,嵌密封膏→贴面砖
2、粘贴XPS板
2.1工具明细
锯条或刀锯
打磨XPS板的粗砂纸、挫子或专用工具
小压子或铁勺
铝合金靠尺
铁卷尺
线绳、线坠
墨斗
2.2配料工具
铁灰槽(建议1M*0.4M*0.3M)
小铁平锹
提漏(1Kg/个或5Kg/个)
塑料桶(建议能装15Kg水泥作为量桶)
2.3粘贴XPS板
2.3.1配制聚合物粘接砂浆必须有专人负责,以确保搅拌质量。
2.3.2将袋装抹面砂浆(干粉)倒入铁灰槽中,适度搅拌,以保证均匀。
2.3.3将水倒入铁灰槽中进行搅拌,聚合物粘接砂浆配合比为:
粘接砂浆(干粉):
水=5:
1(重量比)。
搅拌必须均匀,避免出现离析,呈粥状。
2.3.4聚合物粘接砂浆应随用随配,配好的聚合物粘接砂浆应在2小时之内用光。
聚合物粘接砂浆应于阴凉处放置,避免阳光曝晒。
2.3.5XPS板粘贴前若墙体干燥应预先撒水湿润,XPS板自下而上逐步粘贴,贴板前应先挂好垂直线、水平线,跟线贴板。
上下两层板必须错缝搭接,搭接长度不宜小于1/3板长,阴阳角处咬茬搭接。
2.3.6XPS板粘贴时,先在板四周抹上50MM宽的砂浆,然后在苯板上打点,如每块板上(1200MM*600MM为例)8个点,边缘点距板边250MM为宜,砂浆点直径为60MM左右,厚度10MM;粘贴直径100MM,厚度为2-3MM,点中心距为200MM,粘贴墙体面积为XPS板的40%。
2.3.7门窗洞口周边、勒角、变形缝、女儿墙及其它预埋件周边打满聚合物粘结砂浆,带宽60MM,厚度10MM,再在XPS板(1200MM*600MM)余下部分涂8个点,粘贴墙体面积为XPS板的50%。
2.3.8贴XPS板时,所有粘结点与基层同时接触,双手用力均匀左右揉动5-7次,使聚合物粘结砂浆与墙面粘牢。
2.3.9粘贴XPS板时,先从门窗洞口周边开始粘贴,需切割的板块放在中间。
2.3.10雨蓬、勒角、变形缝处粘贴时应做翻包处理,将宽度200MM-260MM的标准耐碱网格布与墙面粘结,粘结宽度为70MM。
2.3.11基层上粘贴XPS板,板与板之间的缝隙不得大于2MM,板面垂直、平整,允许偏差不超过3MM,板面高低差不得超过1.5MM。
2.3.12粘贴时挤出的聚合物粘结砂浆应用灰刀清除干净。
2.3.13对下料尺寸偏差或切割等原因造成的板间小缝,应用XPS板裁成合适的小片塞入缝中。
2.3.14XPS板粘贴一定面积后,用2M靠尺进行检查,将板压平、压实,进行初步找平,为下一道工序做好准备。
2.3.15待XPS板粘贴24小时后方可进行打磨,用粗砂纸、挫子或专用工具对整个墙面打磨一遍,打磨时不要沿板缝平行方向,而是作轻柔圆周运动将不平处磨平,墙面打磨后,应将XPS板碎屑清扫干净,随磨随用2M靠尺检查平整度。
2.3.16热镀锌钢丝网及锚固至少在XPS板粘贴24小时后才能进行施工,并保证先安排朝阳面安装工序。
2.3.17XPS板板边除有翻包耐碱网格布的可以在XPS板侧面涂抹聚合物粘结砂浆,其它情况均不得在XPS板侧面涂抹聚合物粘结砂浆。
3、粘贴热镀锌钢丝网及锚固
3.1工具明细
铁灰槽(建议1M*0.4M*0.3M)
刀或剪刀
小铁平锹
铁抹子
提漏(1Kg/个或5Kg/个)
塑料桶(建议能装15Kg水泥作为量桶)
线绳、线坠
刷子
小压子
木板条(截面为25MM*15MM*10MM)
3.2粘贴热镀锌钢丝网及锚固
3.2.1配置聚合物抹面砂浆必须专人负责,以确保搅拌质量。
3.2.2将袋装抹面砂浆(干粉)倒入铁灰槽中,适度搅拌,以保证均匀。
3.2.3将水倒入铁灰槽中进行搅拌,聚合物抹面砂浆配合比为:
抹面砂浆(干粉):
水=5:
1(质量比)。
搅拌必须均匀,避免出现离析,呈粥状。
3.2.4聚合物抹面砂浆应随用随配,配好的聚合物抹面砂浆应在2个小时之内用完,聚合物砂浆抹面砂浆应于阴凉处放置,避免阳光曝晒。
3.2.5按预先需要的长度、宽度从整卷热镀锌钢丝网上剪下网片,留出必要的搭接长度或重叠部分的长度。
3.2.6在干净平整的地方剪断,下料必须准确,剪好的钢丝网必须卷起来,不允许折叠,不允许踩踏。
3.2.7抹第一遍聚合物抹面砂浆前,应保持XPS板面干燥,去除板面有害物质或杂质。
3.2.8铺设热镀锌钢丝网时,网布的弯曲面朝向墙体,压紧钢丝网使其紧贴在保温系统表面,并及时用尼龙锚固件固定,再在其上施抹一层聚合物抹面砂浆,厚度不小于3MM。
3.2.9钢丝网周边搭接长度不得小于70MM,在被切断的部位,应采用热镀锌钢丝绑牢。
3.2.10门窗膀周边应做翻包加强处理(与耐碱网格布复合完成),大墙面铺设的钢丝网应嵌入门窗框侧粘牢。
3.2.11钢丝网铺设完后,应防止硬物撞击而导致变形,容易碰撞的阳角,门窗应采取保护措施,上料口部位采取防污染措施,发生表面损坏、污染或变形必须立即处理。
3.2.12第一遍抹面砂浆施工12小时后,再抹第二遍抹面砂浆,起到覆盖钢丝网及找平作用。
3.2.13施工后保护层4小时内不能被雨淋。
3.2.14保护层终凝后及时喷水养护,昼夜平均气温高于15度时不得少于48小时,低于15度时不得少于72小时。
(英文版)
Tworegulationspromulgatedforimplementationisinthepartyinpowerforalongtimeandtheruleoflawconditions,theimplementationofcomprehensivestrictlystrategicplan,implementationinaccordancewiththerulesanddisciplinetomanagetheparty,strengtheninner-partysupervisionofmajorinitiatives.Thetworegulationssupportingeachother,theadheretoapositiveadvocate,focusingonmoralityisofPartymembersandPartyleadingcadrescansee,enoughtogetahighstandard;aroundthepartydiscipline,disciplinaryrulerrequirements,listedas"negativelist,focusingonverticalgauge,drawthepartyorganizationsandPartymembersdonottouchthe"bottomline".Here,themainfromfoursquarefacetwopartyrulesofinterpretation:
thefirstpartintroducestwopartyRevisedregulationsthenecessityandtherevisionprocess;thesecondpartistheinterpretationofthetwofundamentalprinciplesoftherevisionoflawsandregulationsintheparty;thethirdpartintroducestwopartyregulationsmodifiedthemainchangesandneedstograspseveralkeyproblems;thefourthpartonhowtograsptheimplementationofthetworegulationsoftheparty.andrevisedthenecessityandrevisedhistoryoftheCPCCentralCommitteetheamendmenttotheChineseCommunistPartymembersandleadingcadreshonestpoliticsseveralguidelines>andcolumn1by2015tostrengthenpartylawsandregulationsfocus.TwopartyregulationsrevisionworklastedaYears,poolingthewisdomofthewholeparty,ideologicalconsensus,drawhistoricalexperience,respectforthewisdomofourpredecessors,whichreflectstheunityofinheritanceandinnovation;followthecorrectdirection,graspthelimitedgoals,adheretotheparty'sleadership,tosolvethemassesofthepeoplereflectafocusontheproblem.Thenewrevisionoftheand,reflectstheparty's18andtheeighthsessionofthethird,thespiritofthefourthplenarysession,reflectingtheexperienceofstudyingandimplementingtheGeneralSecretaryXiJinpingseriesofimportantspeech,reflectstheparty'seighteenyearscomprehensivestrictlypractice.(a)revisedtworegulationsofthepartyneedofinbasedonrevised,thepromulgationandimplementationofJanuary2010,tostrengthentheconstructionofthecontingentofleadingcadresplayanimportantrole.Butwiththepartytomanagethepartystrictlyadministeringthedeepening,hasnotbeenabletofullymeettheactualneeds.Contentistoocomplicated,"eightprohibition,52arenotallowedto"hardtoremember,andalsodifficulttoputintopractice;thesecondisconciselypositiveadvocatedbythelackofprohibitedprovisionsexcessive,noautonomyrequirements;thethirdisbannedtermsanddisciplinelaw,bothwiththepartydiscipline,disciplinaryregulationsrepeatandCriminallawandotherlawsandregulationsrepeat;thefourthisto"clean"thethemeisnotprominent,notfortheexistingproblems,andisnarrow,onlyneedleofcounty-levelleadingcadresabove.isin1997basedonrevision,inDecember2003thepromulgationandimplementation,tostrengthentheconstructionofthepartyplayveryimportantrole.Alongwiththedevelopmentofthesituation,whichmanyprovisionshavebeenunabletofullymeetthecomprehensivestrictlyadministeringthepracticeneeds.OneisJilaw,morethanhalfoftheprovisionsandcriminallawandothercountrieslawsandregulationsRepetition;twoisthepoliticaldisciplineregulationsisnotprominent,notspecific,forviolationofthepartyconstitution,damagetheauthorityofPartyConstitutionofmisconductlacknecessaryandseriousresponsibilitytopursue;thirdisthemaindisciplinefortheleadingcadres,doesnotcoverallPartymembers.Basedontheabovesituation,needtoandthetwoislikelytobemorerelevantregulationsfirstamendment.Byrevising,reallyputtheauthorityofPartydiscipline,theseriousnessinthepartytreeandcallupthemajorityofPartymembersandcadresofthepartyconstitutionofpartycompassespartyconsciousness.(II)twopartyregulationsrevisionprocesstheCentralCommitteeoftheCommunistPartyofChinaattachesgreatimportancetotworegulationsrevision.XiJinping,generalbooksrecordedintheFifthPlenarySessionoftheeighthsessionoftheCentralCommissionforDisciplineInspection,ontherevisedregulations<>madeclearinstructions.Accordingtothecentraldeployment,theCentralCommissionforDisciplineInspectionfrom2014undersixmonthsbeginstudytworegulationsrevision.TheStandingCommitteeoftheCentralCommissionforDisciplineInspection4reviewrevised.ComradeWangQishan14timesheldaspecialmeetingtostudytworegulationsrevision,amendmentclarifiesthedirection,majorissuesofprinciple,pathandtarget,respectivelyheldaforumwilllistentopartoftheprovince(area)secretaryofthePartycommittee,SecretaryoftheDisciplineInspectionCommission,partofthecentralministriesandstateorgansDepartment
Thefirstpartycommitteeismainlyresponsibleforpeople,viewsofexpertsandscholarsandgrassrootspartyorganizationsandPartymembers.ApprovedbytheCentralCommitteeoftheCommunistPartyofChina,on7September2015,thegeneralofficeoftheCentralCommitteeofthePartyissuedanoticetosolicittheprovinces(autonomousregions,municipalities)Party,thecentralministriesandcommissions,stateministriesandcommissionsoftheParty(party),theGeneralPoliticalDepartmentofthemilitary,every3peopleorganizationofPartyoftworegulationsrevisionopinion.CentralCommissionforDisciplineInspectionofextensivesolicitationofopinions,carefulstudy,attracting,formedarevisedsentreviewers.InOctober8andOctober12,CentralCommitteePoliticalBureauStandingCommitteeandthePoliticalBureauoftheCentralCommitteeAfterconsiderationofthetworegulationsreviseddraft.OnOctober18,theCentralCommitteeoftheCommunistPartyofChinaformallyissuedtworegulations.Cansay,twolawsamendmentconcentratedthewisdomofthewholeparty,embodiestheparty.Second,andrevisionofthebasicprinciplesoftwopartyregulationsrevisionworkandimplementtheparty'seighteen,teneightplenary,thespiritoftheFourthPlenarySessionoftheEleventhCentralCommitteeandGeneralSecretaryXiJinpingimportantinstructionsontherevisedand,highlightingtherulingpartycharacteristics,seriousdiscipline,thedisciplinequiteinfrontoft