施工现场临时用水文档格式.docx
《施工现场临时用水文档格式.docx》由会员分享,可在线阅读,更多相关《施工现场临时用水文档格式.docx(20页珍藏版)》请在冰豆网上搜索。
4(施工生产用水
楼层施工用水采用贮水池、水泵联合供水方式,泵压水管路与市政水管相连,当市政水压满足时使用市政水,水压不够时,再使用水泵供水,引至楼层施工用水通过管径为DN65的立管引上,立管每层预留一个DN20截止阀。
为了保障现场施工安全、建筑物场地及楼层增设DN65消防管道接口。
三、消防用水设置方案
采用生产用水和消防用水合用一个系统,现场防火采用消火栓系统。
1、现场消火栓布设
现场消防干管环状布置,并按要求布置室外地下式消火栓,具体
安装方法参见国标。
2、楼层消火栓布设
立管每层分别设置一个消火栓接口,可满足要求,消火栓的直径65mm,配备水龙带为25米,充实水柱为10米。
3、办公区和生活区布置干粉式灭火器,不再设置消火栓。
四、临时用水原则
1、管材的选用和连接方法:
本工程办公区和生活区,主干管和市政管网直接供水的用水点采用PP-R管热熔连接,减少漏水点;
楼层生产用水和消防用水采用镀锌钢管焊接。
2(依设计总平面图和获得业主方批准的施工现场平面布置图为总依据,进行管线走向的布置和设计。
3(本着“经济、科学、合理、文明”的原则,最大可能降低临时用水用电的工程成本。
4(分阶段的布置原则,以充分利用市政管网的压力,根据工程特点,分2个阶段来设置临时水电,一阶段为主体施工阶段;
二阶段是装饰施工阶段,其水电的设置方案详见后面章节的阐述。
5(以安全为主的指导思想原则,主要体现在临电、消防设施及维护方面。
6(注重美观,符合文明工地标准和要求为原则整体考虑管线的布置。
7(以方便使用,管理和维护为指导原则,确保施工期内生产生活的供水、排水、供电正常。
五、临时排水设置方案
采用雨、污水分流,附以化粪池,隔油池、沉淀池的排放方式。
在生产区、办公区形成排水管网,并设检查井,其中污水管采用DN300PVC双壁波纹管,雨水管采用DN350双壁波纹管。
1、办公区和生活区污废水排放
卫生间的污水先通过化粪池再排入主排水管,最后排入市政管网;
浴室、洗涤废水直接排入排水管,最后排入市政管网;
食堂排水先通过隔油池,再排入主排水管,最后排入市政管网。
2、办公区和生活区雨水排放
雨水管采用明沟收集,再接入雨水管网,最后接入雨水市政管网。
3、施工区雨水排放
沿施工区四周设明沟收集雨水,并增设沉淀池,雨水通过沉淀池后排入管网,最后接入市政管网。
六、临时用水量计算
1、现场施工高峰期用水量
定额耗水量
序号用水对象工程数量Q1总耗水量
N1
1砼养护用水100(m3)300(l/m3)100
冲洗模板用
2500(m2)5(l/m2)500
水
砌砖工程用
3100(m3)200(l/m3)100
抹灰工程用
4200(m3)30(l/m2)200
5搅拌砂浆50(m3)300(l/m3)50
6合计950(m3)950(m3)
q=K?
(Q?
N/T?
t)?
(K/8×
3600)111112
=1.15×
【950/(29×
2)】×
【1.5/(8×
3600)】
=3.6L/s
式中:
q——施工用水量(L/s);
1
K——未预计的施工用水系数,取1.15;
Q——月度最高峰工程量;
N——施工用水定额;
T——月度有效性作业日,取29天;
T——每天工作班数,取2班;
K——用水不均衡系数,取1.5。
2
2、机械用水量计算:
施工机械用水量计算公式:
其中q2?
?
施工机械用水量(L/s);
K?
未预见的施工用水系数,取1.05;
Q?
同一种机械台数(台),取值如下表;
N?
施工机械台班用水定额,取值如下表;
施工机械用水不均匀系数,取2。
3
施工机械用水定额列表如下:
机械名称型号单位耗水量N1(L)机械台数
Q2换算系数
对焊机-冷拨机台?
h3002
8
经过计算得到q2=1.05×
4800×
2/(8×
3600)=0.35L/S。
3、施工现场生活用水量
q=(P?
N?
K)/(t×
8×
3600)=(800×
60×
1.4)/(2×
83134
×
3600)
=1.2(L/s)
q——施工现场生活用水量(L/s)3
P——施工现场高峰昼夜人数1
N——施工现场生活用水定额,取60L/人?
班3
K——施工现场用水不均衡系数,取1.4;
4
t——每天工作班数,取2班。
4、生活区生活用水量
K)/(24×
120×
2.5/(24×
4245
=2.8L/s
q——生活区生活用水量(L/s)4
P——生活区人数2
N——施工现场昼夜全部生活用水定额,取120;
K——生活区用水不均衡系数,取2.5。
5
5、消防用水量:
q5
施工现场消防用水(25公顷内)15L/s
q=15L/s5
6、总用水量(Q)
q+q+q+q=3.6+0.35+1.2+2.8=7.95L/s,q=15L/s12345
故工地总用水量为Q=15L/s
7、管径的选择
求水源至工地主干管的流量(q)和管径(d)11
d=4Q/(?
v?
1000)=4×
15/(?
25×
1000)=90mm1
施工现场主干管的流量为15L/s
查表得:
管径d=100mm1
消防用水主干管根据《建设工程施工现场消防安全技术规范》
6.3.4第2条规定,选用管径DN100给水管。
但由于现场甲方指
定的水源接驳点的实际情况,该工程采用两处φ63的给水接驳点
接通形成环状管网对施工现场进行供水。
七、施工要求及工艺规程:
首先配合土建施工进度做好管道预留孔洞,位置见平面图。
施工前根据现场测绘草图,在选好的管材上画线,接线断管。
本方案给水管均为PP-R管热熔连接和焊接钢管焊接。
PP-R管道和接头的表面要保证光滑、平整、清洁、无油及水渍;
在管道插入深度处做记号(等于接头的套入深度),在焊接工具上把整个嵌入深度加热,包括管道和接头;
当加热时间完成之后,把管道平稳而均匀地推入接头中,形成牢固紧密美的接合,在管道和接头焊接之后的几秒钟之内,可以调节接头位置。
管道与管件的连接应保证电熔接套和管道同一轴线;
管道与管件连接后,应稳定30-60秒(管径越大,所需时间越长)后,
方可以承受负荷;
管道热熔连接时,要严格按产品操作要求根据管径大小控制加热时间,以避免加热时间不够造成未熔合或加热时间过久造成内瘤。
钢管焊接前要将两管轴线对中,先将两管端部点焊牢,管径在100MM以下可点焊三个点为宜。
焊接应做到:
焊口平直度、焊缝加强面符合施工规范规定,焊波均匀一致。
管道安装前,核对各层预留孔洞位置是否正确,每层从上至下统一吊线安装卡件,将预制好的管道编号分层排开,顺序安装,对好调直,安装完后找正,配合土建看好楼板洞口。
施工用水立管每层设置配水点。
加压水泵安装:
(1)安装前检查水泵和电机的完整情况。
(2)水泵安装前,由土建部门制作为H=200MM高砼基础并根据泵的尺寸;
预留好4个孔洞。
(3)检查泵基础,并准备好工具。
(4)将泵安放的基础上垫高30—40MM,准备填充细石混凝土。
(5)进行找正,并穿好地脚螺栓,填充细石混凝土。
(6)经3—5天水泥干固后,重新找正,并紧固地脚螺栓螺母。
(7)预试底阀严密性,安装进出水管路及阀门。
八、临时用水维护及故障解决方法
1、水泵房设值班人员,有专人维修,当施工用水时开启水泵,如不用水关闭水泵。
2、如临时用水的管道和其它阀件发生漏水现象,立刻通知值班人员将水泵关闭,将管路或阀件修复完成后,再开启水泵。
3、维护人员要对现场的临时用水系统,做到经常检查,发现阀件有不严、渗水、漏水现象,及时更换。
4、水泵不吸水、压力表指针剧烈跳动时,应检查底阀是否漏水,再灌足引水,拧紧漏气处。
5、在运行中,泵的轴承温度不得超过外界温度35?
,其极限温度不得大于75?
6、定期检查联轴器,注意轴承温升。
7、泵在运转中发现有不正常噪音时,应立即停止运转检查其原因。
九、现场临水平面布置示意图(详见附图)
英文版,
Tworegulationspromulgatedforimplementationisinthepartyinpowerforalongtimeandtheruleoflawconditions,theimplementationofcomprehensivestrictlystrategicplan,implementationinaccordancewiththerulesanddisciplinetomanagetheparty,strengtheninner-partysupervisionofmajorinitiatives.Thetworegulationssupportingeachother,the<
code>
adheretoapositiveadvocate,focusingonmoralityisofPartymembersandPartyleadingcadrescansee,enoughtogetahighstandard;
<
rule>
aroundthepartydiscipline,disciplinaryrulerrequirements,listedas"
negativelist,focusingonverticalgauge,drawthepartyorganizationsandPartymembersdonottouchthe"
bottomline"
.Here,themainfromfoursquarefacetwopartyrulesofinterpretation:
thefirstpartintroducestwopartyRevisedregulationsthenecessityandtherevisionprocess;
thesecondpartistheinterpretationofthetwofundamentalprinciplesoftherevisionoflawsandregulationsintheparty;
thethirdpartintroducestwopartyregulationsmodifiedthemainchangesandneedstograspseveralkeyproblems;
thefourthpartonhowtograsptheimplementationofthetworegulationsoftheparty.<
and<
Regulations>
revisedthenecessityandrevisedhistoryoftheCPCCentralCommitteetheamendmenttotheChineseCommunist
Partymembersandleadingcadreshonestpoliticsseveralguidelines>
ChineseCommunistPartydisciplineandPunishmentRegulations>
column1by2015tostrengthenpartylawsandregulationsfocus.TwopartyregulationsrevisionworklastedaYears,poolingthewisdomofthewholeparty,ideologicalconsensus,drawhistoricalexperience,respectforthewisdomofourpredecessors,whichreflectstheunityofinheritanceandinnovation;
followthecorrectdirection,graspthelimitedgoals,adheretotheparty'
sleadership,tosolvethemassesofthepeoplereflectafocusontheproblem.Thenewrevisionofthe<
reflectstheparty'
s18andtheeighthsessionofthethird,thespiritofthefourthplenarysession,reflectingtheexperienceofstudyingandimplementingtheGeneralSecretaryXiJinpingseriesofimportantspeech,reflectstheparty'
seighteenyearscomprehensivestrictlypractice.(a)revisedtworegulationsofthepartyneedof<
theICACguidelines>
in<
in1997LeadersasmembersoftheCommunistPartyofChinacleanpoliticscertaincriteria(Trial)>
basedonrevised,thepromulgationandimplementationofJanuary2010,tostrengthentheconstructionofthecontingentofleadingcadresplayanimportantrole.Butwiththepartytomanagethepartystrictlyadministeringthedeepening,hasnotbeenabletofullymeettheactualneeds.Contentistoo
complicated,"
eightprohibition,52arenotallowedto"
hardtoremember,andalsodifficulttoputintopractice;
thesecondisconciselypositiveadvocatedbythelackofprohibitedprovisionsexcessive,noautonomyrequirements;
thethirdisbannedtermsanddisciplinelaw,bothwiththepartydiscipline,disciplinaryregulationsrepeatandCriminallawandotherlawsandregulationsrepeat;
thefourthisto"
clean"
thethemeisnotprominent,notfortheexistingproblems,andisnarrow,onlyneedleofcounty-levelleadingcadresabove.<
isin1997<
ChineseCommunistPartydisciplinarycases(Trial)>
basedonrevision,inDecember2003thepromulgationandimplementation,tostrengthentheconstructionofthepartyplayveryimportantrole.Alongwiththedevelopmentofthesituation,whichmanyprovisionshavebeenunabletofullymeetthecomprehensivestrictlyadministeringthepracticeneeds.OneisJilaw,morethanhalfoftheprovisionsandcriminallawandothercountrieslawsandregulationsRepetition;
twoisthepoliticaldisciplineregulationsisnotprominent,notspecific,forviolationofthepartyconstitution,damagetheauthorityofPartyConstitutionofmisconductlacknecessaryandseriousresponsibilitytopursue;
thirdisthemaindisciplinefortheleadingcadres,doesnotcoverallPartymembers.Basedontheabovesituation,needto<
thecriterionofacleanandhonest
administration>
thetwoislikelytobemorerelevantregulationsfirstamendment.Byrevising,reallyputtheauthorityofPartydiscipline,theseriousnessinthepartytreeandcallupthemajorityofPartymembersandcadresofthepartyconstitutionofpartycompassespartyconsciousness.(II)twopartyregulationsrevisionprocesstheCentralCommitteeoftheCommunistPartyofChinaattachesgreatimportancetotworegulationsrevision.XiJinping,generalbooksrecordedintheFifthPlenarySessionoftheeighthsessionoftheCentralCommissionforDisciplineInspection,ontherevisedregulations<
>
madeclearinstructions.Accordingtothecentraldeployment,theCentralCommissionforDisciplineInspectionfrom2014undersixmonthsbeginstudytworegulationsrevision.TheStandingCommitteeoftheCentralCommissionforDisciplineInspection4reviewrevised.ComradeWangQishan14timesheldaspecialmeetingtostudytworegulationsrevision,amendmentclarifiesthedirection,majorissuesofprinciple,pathandtarget,respectivelyheldaforumwilllistentopartoftheprovince(area)secretaryofthePartycommittee,SecretaryoftheDisciplineInspectionCommission,partofthecentralministriesandstateorgansDepartment
Thefirstpartycommitteeismainlyresponsibleforpeople,viewsofexpertsandscholarsandgrassrootspartyorganizationsand
Partymembers.ApprovedbytheCentralCommitteeoftheCommunistPartyofChina,on7September2015,thege