双沟镇A2O-MBR设计方案Word文件下载.doc
《双沟镇A2O-MBR设计方案Word文件下载.doc》由会员分享,可在线阅读,更多相关《双沟镇A2O-MBR设计方案Word文件下载.doc(114页珍藏版)》请在冰豆网上搜索。
评阅老师
二○一○年六月
中国南京
摘要
随着社会的发展,国家对城市污水排放的要求越来越高。
为改善双沟镇的水体环境,使双沟镇的污水能够得到全面的收集和完善的处理,拟建设一污水处理厂,设计中污水厂服务的人口为近期5万人,远期11万人。
设计管网服务的面积为1712.13公顷,工程总造价为10950.15万元。
排水管网设计时,根据城镇的地形趋势,将整个城镇划分成了四个排水区域,然后通过提升泵站将各区的污水提升至污水处理厂。
污水厂设计规模为:
近期2万吨/d,远期6万吨/d。
设计进水水质为:
悬浮物(SS):
239mg/L;
五日生化需氧量(BOD5):
317mg/L;
化学需氧量(CODcr):
221mg/L;
总氮(TN):
32mg/L;
总磷(TP):
4mg/L;
氨氮(NH3-N):
30mg/L。
设计出水标准达到《城镇污水处理厂污染物排放标准》(GB18918-2002)一级A标准,即:
悬浮物(SS)≤10mg/L;
五日生化需氧量(BOD5)≤10mg/L;
化学需氧量(CODcr)≤50mg/L;
总氮(TN)≤15mg/L;
总磷(TP)≤0.5mg/L;
氨氮(NH3-N)≤5mg/L。
为达到出水标准,本设计采用A2/O-MBR工艺处理双沟镇的污水。
与传统活性污泥工艺相比,MBR对含碳有机物的去除有以下特点:
去除率高,一般大于90%,出水达到回用水的指标;
污泥负荷(F/M)低;
所需水利停留时间(HRT)短,容积负荷高,刚冲击负荷能力强。
而膜生物反应器用膜组件替代了传统的二沉池进行固液分离,由于膜的高截留率并将浓缩污泥回流到生物反应器内,而使生物反应器内具有很高的微生物浓度和很长的污泥停留时间,所以MBR法可以在比传统活性污泥法更短的水力停留时间内达到更好的去除效率。
本设计的理念是利用MBR膜池代替传统工艺中的二沉池,在A2/O生物池对污水进行脱氮除磷的基础上,膜池达到进一步深度处理的效果。
为解决出水中总磷的含量不太稳定的问题,在膜池的进水端进行加药除磷。
设计中主要构筑物包括粗格栅、提升泵房、细格栅、旋流式沉砂池、A2/O生物池、MBR膜池、接触消毒池、贮泥池、脱水机房等。
市政污水管网收集的污水经中格栅拦截较大的悬浮物和漂浮物后,由污水泵房提升至细格栅和旋流式沉砂池去除比重较大的无机颗粒,在经过生物池脱氮除磷后再通过膜池对污水中剩余的有机物质及氮磷进一步降解去除,处理后的污水经氯消毒后排放。
在整个处理工程中,污泥回流比为100%,其余的由污泥脱水机房浓缩脱水后外运。
在该处理工艺下,最终排放的污水达到国家一级A标准,符合设计要求。
关键词:
污水处理,A2/O-MBR工艺,一级A标准
ABSTRACT
Withthedevelopmentofoursociety,thestandardoftheurbansewagedischargethatthestaterequiresarehigherandhigh.Toimprovetheenvironmentshuanggoutown‘swater,collectthiswatercomprehensivelyanddealwithitcomprehensively,thestateplanstobuildasewagetreatmentplant.Inthisdesignthewastewatertreatmentplantservicesapopulationof5millionpeoplerecentlyand11millionlong-term.Thepipenetworkservices1,712.13hectaresandthetotalcostoftheprojectis109.5015milliondorall.Duringthedesignofthepipenetwork,wedividetheentiretownintofourdrainageareasaccordingtotheurbanterrain,andthenupgradethesewagetothesewagetreatmentplantbypump.
Thedesignscaleofthiswastewatertreatmentplantis20,000tons/dforrecentand60,000tons/dforlong-term.Designqualityofenterwaterare:
suspendedsolids(SS):
239mg/L;
theoxygendemandforbiochemistryinthe5days(BOD5):
317mg/L;
oxygendemandforbiochemistryinthe5days(BOD5):
oxygendemandforchemistry(CODcr):
221mg/L;
totalnitrogencontents(TN):
32mg/L;
totalphosphoruscontents(TP):
4.0mg/L;
ammonianitrogencontents(NH3-N):
30mg/L.ThedesignedeffluentstandardscanachievetogradeAstandards,whichcomesfrom"
MunicipalWastewaterTreatmentPlant’sEmissionStandardsofPollutant"
(GB18918-2002).Namely:
suspendedsolids(SS)≤10mg/L;
theoxygendemandforbiochemistryinthe5days(BOD5)≤10mg/L;
oxygendemandforchemistry(CODcr)≤50mg/L;
totalnitrogencontents(TN)≤15mg/L;
totalphosphoruscontents(TP)≤0.5mg/L;
ammonianitrogencontents(NH3-N)≤5mg/L.
Toachievetheeffluentstandards,thedesignusesA2/O-MBRProcesstotreattheurbansewagewaterofshuanggou.Comparedwithconventionalactivatedsludgeprocess,MBRprocesshasthefollowingcharacteristicsontheremovaloforganiccarbon:
Removalrateishighthatcanbegenerallygreaterthan90%andtheeffluentwatercanreachthetargetofreusewater;
sludgeloading(F/M)islow;
hydraulicretentiontime(HRT)thatrequiredisshort.What’smore,ithashigh-volumeloadandstrong–capabilityofshockload.MembraneBiologicalReactorreplacesthetraditionalsecondaryseparationofsolidwithmembraneinordertoseparatesolidandliquid.Asthefilmhashighretentionrateanditcanreturntheconcentratedsludgebacktothebioreactorsothatthebioreactorcanhavemicroorganismwithhighconcentrationandalongsludgeretentiontime.ComparedwithconventionalactivatedsludgeprocesstheMBRprocesscanachievebetterremovalefficiencywithshorterhydraulicretentiontime.TheconceptofthisdesignisreplacingthesecondarysettlingtankinthetraditionalprocesswithMBRmembranepool.OnthebasisoftheA2/Obiologicalsewagepool’sremovalfornitrogenandphosphorus,membranepoolhasthefurthertreatmentfunction.Tosolvetheproblemthatthecontentoftotalphosphorusineffluentisnotstable,weaddspecificpharmaceuticaltotheintakedepartmentofmembranepoolforremovingphosphorus.
Themainstructuresofthetreatmentprocessincludemediumbarscreen,sewagepumpingstation,thinbarscreen,Vortex-typegritchamber,A2/Obiologicalpool,MBRmembranepool,Chlorineconcentrationtank,Storagebasins,sludgedehydrationshopetc.Inpreliminarytreatment,theoriginalwaterentersmediumscreeninginordertoremoveheavysolidsandfloatablematerials,incasethatitinfluencestheworkingofthefollowingdevicesandthepipelines.Thenitentersvortex-typegritchamber,whichisusedtoremovebiggerinorganicsand