港口码头船岸检查表.docx

1、港口码头船岸检查表船/岸安全检查表SHIP/SHORE SAFETY CHECK LISTShips Name 船名 . Berth 泊位 Port 港口 .Date of Arrival 抵达日期 .Time of Arrival抵达时间 . 填表须知INSTRUCTIONS FOR COMPLETION:为保证安全作业，下列所有问题的答复均是肯定的,可在相应的方格内清楚地打上()标号。如果不能给予肯定回答，应说明理由，而且船舶和码头之间均达成关于应采取的适当预防措施的协议。如果认为有的问题不适用，应在备注栏里加以说明。The safety of operations requires th

2、at all questions should be answered affirmatively by clearly ticking () in the appropriate box. If an affirmative answer is not available, the reason should be given and agreement reached upon appropriate precautions to be taken between the ship and the terminal. Where any question is considered to

3、be not applicable, then a note to that effect should be inserted in the remarks column.“船舶”和“码头”栏目下的方格，表示由负责方实施检查。A box in the column ship and terminal indicates that the party concerned should carry out checks. 在“代码”栏目里的A，P或R字母，分别表示如下的意义：The presence of the letters A, P or R in the column Code indi

4、cates the following:A （协议）表示该检查项应通过协议或程序来处理，并在检查表中的“备注”栏中明确或者通过其它一些双方可接受的表格来交流这些协议和程序。A (Agreement). This indicates that the referenced consideration should be addressed by an agreement or procedure that should be identified in the Remarks column of the Check List, or communicated in some other mutu

5、ally acceptable form. P（批准）在否定回答的情况下，未经主管当局的书面许可，不可进行作业。P (Permission). In the case of a negative answer to the statements coded P, no operations are to be conducted without the written permission from the appropriate authority.R（复查） 表示在不超出声明同意的时间间隔须重复检查的项目。R (Re-check). This indicates items to be r

6、e-checked at appropriate intervals, as agreed between both parties and stated in the declaration.仅在所有方检查和接受他们分配的职责和责任后方可签署共同声明The joint declaration should not be signed until all parties have checked and accepted their assigned responsibilities and accountabilities.PART A BULK LIQUID GENERAL - PHYSI

7、CAL CHECKSA 部分 散装普通液货 现场核实Bulk Liquid General 散装液体 普通Ship船舶Terminal码头Code代码Remarks备注1. There is safe access between the ship and shore.船岸之间有安全通道.R2. The ship is securely moored. 船舶已安全系泊.R3. The agreed ship/shore communication system is operative. 商定的船/岸通信系统可用.A RSystem 系统 .Back up system 备用系统.4. Eme

8、rgency towing-off pennants are correctly rigged and positioned.应急拖缆已带好并处于正确位置.R5. The ships fire hoses and fire-fighting equipment are positioned and ready for immediate use. 船方消防水带和消防设备配置在位并立即可用.R6. The terminals fire-fighting equipment is positioned and ready for immediate use. 岸方消防设备配置在位并立即可用.R7.

9、 The ships cargo and bunker hoses, pipelines and manifolds are in good condition, properly rigged and appropriate for the service intended.船方的货物、燃油软管, 管线和集管处于良好状态，适当固定并适用于预计的货物作业.8. The terminals cargo and bunker hoses/arms are in good condition, properly rigged and appropriate for the service inten

10、ded.岸方的货物、燃油软管/装卸臂处于良好状态，适当固定并适用于预计的货物作业.9. The cargo transfer system is sufficiently isolated and drained to allow safe removal of blank flanges prior to connection.接管前，货物转移系统有效隔离并放残以能够安全地拆除盲板.10. Scuppers and save alls on board are effectively plugged and drip trays are in position and empty.船上的排水

11、孔和积油槽有效塞堵，空的集液盘放置到位。RBulk Liquid General 散装液体 普通Ship船舶Terminal码头Code代码Remarks备注11. Temporarily removed scupper plugs will be constantly monitored.临时移开流水孔塞需保持监控。R12. Shore spill containment and sumps are correctly managed.岸方的溢油围堰和积油槽正确管理R13. The ships unused cargo and bunker connections are properly

12、secured with blank flanges fully bolted.船方不用的货物、燃油管接头已装妥盲板并上紧全部螺栓.14. The terminals unused cargo and bunker connections are properly secured with blank flanges fully bolted.岸方不用的货物、燃油管接头已装妥盲板并上紧全部螺栓.15. All cargo, ballast and bunker tank lids are closed.所有货舱、压载舱和燃油舱舱盖都保持关闭。16. Sea and overboard disc

13、harge valves, when not in use, are closed and visibly secured. 海底阀和舷外排出阀在不使用时已关闭和确实关妥.17. All external doors, ports and windows in the accommodation, stores and machinery spaces are closed. Engine room vents may be open. 居住舱室、储物间和机器处所的所有外部门,开口和窗户已关闭. 机舱的通风可以打开.R18. The ships emergency fire control p

14、lans are located externally. 船舶紧急消防控制图放置在外部.Location 位置 . If the ship is fitted, or is required to be fitted, with an Inert Gas System (IGS) the following points should be physically checked:如船舶安装有，或要求安装惰气系统(IGS)，下列各条应进行现场核查：Inert Gas System 惰气系统Ship船舶Terminal码头Code代码Remarks备注19. Fixed IGS pressure

15、and oxygen content recorders are working. 固定式的惰气系统压力和氧含量记录器正常工作R20. All cargo tank atmospheres are at positive pressure with oxygen content of 8% or less by volume. 所有货舱均为正压，氧气含量8% (体积)P RPART B BULK LIQUID GENERAL VERBAL VERIFICATIONB 部分散装普通液货 口头确认Bulk Liquid General 散装液体 普通Ship船舶Terminal码头Code代码Re

16、marks备注21. The ship is ready to move under its own power. 船舶能够随时靠自航移位.P R22. There is an effective deck watch in attendance on board and adequate supervision of operations on the ship and in the terminal. 船上安排了有效的甲板值班, 码头和船上有足够的监督人员.R23. There are sufficient personnel on board and ashore to deal wit

17、h an emergency. 船上和岸上有足够人员应付紧急情况.R24. The procedures for cargo, bunker and ballast handling have been agreed 货物、燃油和压载的装卸程序已议定.A R25. The emergency signal and shutdown procedure to be used by the ship and shore have been explained and understood解释并理解船岸之间使用的应急信号和应急关闭程序A26. Material Safety Data Sheets

18、(MSDS) for the cargo transfer have been exchanged where requested.作业货物的物质安全数据单已按要求进行交换P R27. The hazards associated with toxic substances in the cargo being handled have been identified and understood.作业货物中所含有毒物质的相关危害已辨识并清楚。H2S Content .硫化氢含量：Benzene Content 苯含量：.28. An International Shore Fire Conn

19、ection has been provided. 已提供国际通岸接头29. The agreed tank venting system will be used.将使用协议的货舱透气系统A R Method方法 .Bulk Liquid General 散装液体 普通Ship船舶Terminal码头Code代码Remarks备注30. The requirements for closed operations have been agreed.封闭作业要求已达成协议R31. The operation of the P/V system has been verified.压力/真空系统

20、的操作已核验32. Where a vapour return line is connected, operating parameters have been agreed.如果接气相回流管，操作参数已达成协议A R33. Independent high level alarms, if fitted, are operational and have been tested.如果安装了独立的高液位报警，应处于工作状态并经测试A R34. Adequate electrical insulating means are in place in the ship/shore connect

21、ion.船/岸接管处有足够的电气绝缘方式A R35. Shore lines are fitted with a non-return valve or procedures to avoid back filling have been discussed.岸线装有止回阀，或已讨论如何避免“倒灌”的程序P R36. Smoking rooms have been identified and smoking requirements are being observed. 指定吸烟室，遵守吸烟规则.A RNominated smoking rooms指定的吸烟室:.37. Naked lig

22、ht regulations are being observed.遵守明火规则A R38. Ship/shore telephones, mobile phones and pager requirements are being observed.遵守船/岸电话、手机和传呼机使用规则A R39. Hand torches (flashlights) are of an approved type.手电筒（闪光灯）为认可型40. Fixed VHF/UHF transceivers and AIS equipment are on the correct power mode or swit

23、ched off.固定式高频/甚高频电话和自动识别系统设备处于正确的发射功率模式或关闭.41. Portable VHF/UHF transceivers are of an approved type.便携式高频/甚高频无线电收发机为认可型.Bulk Liquid General 散装液体 普通Ship船舶Terminal码头Code代码Remarks备注42. The ships main radio transmitter aerials are earthed and radars are switched off.船舶主无线电发射天线接地，雷达处关闭状态43. Electric ca

24、bles to portable electrical equipment within the hazardous area are disconnected from power.在危险区域内便携式电气设备的电缆断开电源44. Window type air conditioning units are disconnected.窗式空调电源断开45. Positive pressure is being maintained inside the accommodation, and air conditioning intakes, which may permit the entry

25、 of cargo vapours, are closed 居住舱室内保持正压，可能吸入货物蒸汽的空调吸入口应关闭46. Measures have been taken to ensure sufficient mechanical ventilation in the pump room.已采取措施保证泵房足够的机械通风R47. There is provision for an emergency escape.预留有应急逃生通道.48. The maximum wind and swell criteria for operations have been agreed.作业的最大风力

26、和涌浪标准已经达成协议AStop cargo at: .停止作业Disconnect at: .拆管Unberth at: .离泊49. Security protocols have been agreed between the Ship Security Officer and the Port Facility Security Officer, if appropriate. 如果适用，船舶保安员和港口设施保安员达成保安协议。A50. Where appropriate, procedures have been agreed for receiving nitrogen suppl

27、ied from shore, either for inerting or purging ships tanks, or for line clearing into the ship.如果需要从岸方接收氮气用于惰化船舱、驱气或吹扫管线，就相关程序已达成协议A PIf the ship is fitted, or is required to be fitted, with an Inert Gas System (IGS) the following statements should be addressed.如果船舶安装了，或被要求安装惰气系统(IGS)，下列各条应进行实际检查：In

28、ert Gas System 惰气系统Ship船舶Terminal码头Code代码Remarks备注51. The IGS is fully operational and in good working order. 惰气系统可完整运行并处于良好工作状态P52. Deck seals, or equivalent, are in good working order. 甲板水封或类似装置处于良好工作状态R53. Liquid levels in pressure/vacuum breakers are correct.压力/真空破断器的液位正常R54. The fixed and porta

29、ble oxygen analysers have been calibrated and are working properly. 固定式和便携式的氧气分析仪已校准并且能够正常工作.R55. All the individual tank IGS valves (if fitted) are correctly set and locked. 各舱的惰气系统阀门（如果已安装）正确设置并上锁.R56. All personnel in charge of cargo operations are aware that in the case of failure of the Inert Gas Plant, discharge operations should cease, and the terminal be advised.所有负责货物作业的人员意识到，