衣车油MSDS.docx

1、衣车油MSDS第一部分：化学品名称及企业标示Section 1 Chemical Product and Company Identification化学品中文名称：衣车润滑油系列Product Name：DJW Clothes vehicle lubricating oil series商品名：衣车润滑油Commodity Name ：Clothes vehicle lubricating oil样品编码：1196121Sample Code：1196121产品性质：Q/SH303 234-2004Product Nature ：Q/SH303 234-2004第二部分：成份/组成信息Sec

2、tion 2 Complsition/Information on Ingredient纯品/Sterling 混合物/ Mixture成份Composition CAS NO.矿物油 White mineral oil 8042-47-5防锈油 Pickling oil 61789-51-3润滑剂 Lubricant 57-09-0抗氧剂-methylenebis(6-tert-butyl-4-methyl-phenol) 119-47-1抗磨剂 Antiwear additive 150-60-7第三部分：危险性概述Section 3 Hazards Identification危险性类别

3、/ Risky category： 非危险品/ Non-dangerous material皮肤接触/ Skin contact：刺激皮肤/ Stimulates the skin眼睛接触/ Eye contact：接触眼睛可引起刺激反应/Contacts the eye to be possible to cause the stimulation response食入/The food enter：吞服有害/ Swallows harmfully侵入途径/ Invasion way：吸入、食入/ The inspiration, the food enter健康危害/ Health dan

4、ger：吸入、食入后会有引起恶心、头晕/ After the inspiration, the food enter, will have causes, dizziness disgusting环境危害/ Environment harm：轻微刺激味，大量存在时可能对自然生物产生分解作用/ Slight stimulation taste, when massive existences possibly has the decomposition to the natural biology燃爆危险/ Explosive danger：遇明火、高热可燃/ Meets the open fi

5、re, the high fever to be inflammable第四部分：急救措施Section 4 First Aid Measures皮肤接触/ Skin contact：脱去污染的衣着，用大量流动清水冲洗，如不适请就医/Takes off the pollution the attire, with massive mobile clear water flushing, if ill please go see a doctor眼睛接触/ Eye contact：提起眼睑，用流动清水或生理盐水冲洗，立即就医/ Speaking of the eyelid, with the f

6、lowing clear water or the physiological saline flushing, goes see a doctor immediately吸入/ The inspiration：小量吸入无需特殊防护，长时间接触应保持通风/ The small amount inspiration does not need to protect specially, the long time contact should maintain ventilates食入/The food enter ：误食者饮足量温水、催吐，立即送医/Harms the trencherman

7、to drink the sufficiency lukewarm water, to urge to spit, delivers the medicine immediately第五部分：消防措施Section 5 Fire Fighting Measures危险特性/Dangerous characteristic：易燃、生理惰性、良好的化学稳定性/ Flammable, physiological inertia, good chemical stability闪点/ Flash point：310灭火方法及灭火剂/Fire fighting method and fire-extin

8、guishing：泡沫、干粉、二氧化碳、气化液体灭火剂/ Froth, dried noodles, carbon dioxide, gasified liquid fire-extinguishing不适用的灭火剂/Not suitable fire-extinguishing：卤化灭火剂或水无效/ The halogenate fire-extinguishing or the water are invalid燃烧产物/Combustion product：一氧化碳、二氧化碳，也可能产生一些有毒气体/ CO、CO2， Also possibly produces some noxious

9、 gases防护设备/ Preventer ：自主呼吸器，密封保护服/ Independent respirator, seal protection clothing第六部分：泄漏应急处理Section 6 Accidental Release Measures应急处理/Emergency processing：a.切断火源，人员迅速撤离泄漏污染区到安全地带进行隔离/ The cut-off fire hazard, the personnel evacuate the divulging contaminated zone to carry on the isolation rapidly

10、 to the safety zoneb.用惰性吸附材料吸收，置于适当的容器中，按相应法律法规废弃/ With the inert adsorption material absorption, puts in the suitable vessel, abandons according to the corresponding laws and regulationsc.用水和清洁剂清洗污染区域/ Water used and cleanser clean contaminated area d.若小量泄漏，用水和清洁剂清洗污染区域,避免与火和高热接触即可/ If small amount

11、 divulging, the water used and the cleanser clean contaminated area, avoids with the fire and the high fever contact then e.若大量泄漏，应构筑堤围或挖坑收容，用泡沫盖严、降低蒸汽灾害，保护现场人员离开。用防爆泵转移至专用容器内，回收后按相关法律法规处理/ If divulges massively, should construct the dike or dig the pit to accept, covers securely with the froth, red

12、uces the steam disaster, protects the scene personnel to leave. With guards against explosions the pump to shift to the special-purpose vessel, after the recycling, according to related laws and regulations processing环境影响/Environmental effect：远离水源，禁止随意丢弃/Is far away from the water source, forbids to

13、 discard at will第七部分：操作处置与储存Section 7 Operation Handling and Storage标示/ Indication：包装件上应有清晰牢固的标志、标明产品名称、型号、质量等级、净重和生产厂名等/ Wraps on the support to have the clear reliable symbol, the mark product range, the model, the quality scale, the net weight and the production plant name and so on包装/ Packing：产品

14、应包装在清洁、干燥、封闭良好的镀锌铁皮桶或塑料桶中，每一包装件应附有产品生产喷码、使用说明、注册专利号、产品标准号/ The product should pack, in clean, dry, the seal good galvanized iron sheet barrel or models in the feeding trough。 Each package of supports should attach the product manufacturing to spurt the code, the operating instructions, the registrat

15、ion patent number, the product standard number运输/ Transportation：本产品在运输中应注意防晒、防潮和防止碰撞/ This product should pay attention in the transportation against exposes to the sun, moisture-proof and prevents la to hit. 贮存/ Storing：a.贮存于密闭容器内置于阴凉、干燥通风的仓库，室温不超过30/Storing in the airtight container built-in cool

16、, the dry well ventilated warehouse, the room temperature does not surpass 30b.贮存区应配套相应的消防器材、禁止烟火/ The storing area should form a complete set the corresponding fire equipment, to forbid the smoke and firec.贮存区所有的照明设施应采用防爆型，开关应设在室外/ The storing area all illumination facility should use the explosion

17、-proof, the switch should be located in outdoord.产品不用时应加以密封，需与氧化剂、酸性、卤素产品分开存放/ The product does not use should perform to seal, must with the oxidant, acidic, the halogen product separate depositinge.存放限高1.5米，远离食物、水源、饲料/ Depositing limits the height 1.5 meters, is far away from food, the water sourc

18、e, the feedf.本品使用期限为三年，超过期限可重检，如符合要求可继续使用/ This life is three years, surpasses the deadline to be possible to examine again, if meets the requirement to be possible to continue to use第八部分：接触控制/个体防护Section 8 Exposure Controls/Personal Protection最高容许浓度/ Maximal allowable concentration：N/A工程控制/Engineer

19、ing control：a.分开使用时应采取不会产生为花的接地通风系统/ Separates when the use should adopt will not produce for the colored earth ventilation systemb.排气口直接通到室外，保持供给室内充分的新鲜空气/ Outside the air vent passes through directly, maintains the supplies indoor full fresh airc.罐装时要有防火防爆技术措施，禁止使用易产生火花的设备和工具/ Canned when must hav

20、e the fire protection explosion-proof technical measure, forbids to use easy to produce the spark equipment and the tool呼吸系统防护/Respiratory system protection：防泄漏、加强通风，配戴口罩，必要使用自给式呼吸机/ Against divulging, strengthens ventilates, has ones eyes tested and wear glasses the mouthpiece, the essential use is

21、 self-sufficient the type life-support machine眼睛防护/ Eye protection：无需特别护理，必要时可戴化学安全防护眼镜/ Does not need the special care, when the necessity may wear the chemical safety snow glasses身体防护/ Bodily protection：无需特别护理/ Does not need the special care手防护/ Hand protection：直接接触戴乳胶手套/ The immediate contact wea

22、rs the emulsion glove其他防护/ Other protections：工作场所禁止吸烟、进食和饮水，饭前要洗手。工作完毕，淋浴更衣。保持良好的卫生习惯/ The operational site no smoking, the feed and the potable water, before meals must wash the hands. The work finished, showers changes clothes. Maintains the good hygienic custom 第九部分：理化特性Section 9 Physical and Che

23、mical Properties外观与形状/Outward appearance and shape：淡黄色油性液体/Faint yellow greasy liquid闪点/ Flash point：140PH值/ PH value：中性/ neutrality密度/ Density：0.9670.975燃爆上限/ Explosive upper limit：158% 燃爆下限/ Explosive lower limit：11%蒸汽压/ Vapor tension：N/A蒸汽密度/ Vapor density ：N/A折射率/ Refractive index：1.4857(20)比重/

24、Proportion：1.0210(20)溶解性/ Solubility：不溶于水，溶于醇、醚、酮、脂、烃等到大部分有机溶液/ Does not dissolve in the water, dissolves mellowly, the ether, the alkone, the fat, the hydrocarbon waits till the majority of organic solutions化学用途/ Chemistry uses：主要用于机器零部件的润滑/ Mainly uses in the machine spare part the lubrication第十部分

25、：稳定性和反应性Section 10 Stability and Reactivity稳定性/ Stability：良好的化学稳定性/ Good chemical stability禁配/ Endures matches：强氧化剂、强碱、强酸/ Strong oxidant, strong alkali, strong acid避免接触的条件/ Avoids condition which contacts ：高温、明火/ High temperature, open fire聚合危害/Polymerization harm：不能发生/Cannot occur分解产物/Decompositio

26、n product：一氧化碳、二氧化碳，也可能产生一些有毒气体/ CO、CO2， Also possibly produces some noxious gases第十一部分：毒理学资料Section 11 Toxicological Information急性毒性/ Acute toxicity：无/ Does not have口服：LD50（鼠）/ Oral administration: LD50 (mouse)：3850mK/Kg 吸入： LC50（鼠）/ Inspiration: LC50 (mouse)：754000/M3静脉注射/Intravenous injection：LD5

27、0（家鼠）：652mK/KgLD50 (house mouse)：652mK/Kg第十二部分：生态学资料Section 12 Ecological Information生态毒性/ Ecology toxicity：当释放至水或土壤中，可能会有生物分解、渗入地下、挥发,对环境有一定的影响/ When releases to the water or the soil, possibly will have the biolysis, permeating underground, the volatility，Dangerous for the environment第十三部分：废弃处理Sec

28、tion 13 Disposal Considerations废弃物处理方法/Reject processing method：a.作为化学废弃品，需参照当地相关法律法规进行处理。或给废弃化学品处理机构/ Abandons as chemistry, must refer to the locality related laws and regulations to carry on processing. Or for abandons the chemical processing organizationb.容器再次使用前彻底清洗干净/ Before the vessel uses on

29、ce more, cleans cleanly thoroughlyc.可参照联合国、国家、地方法律法规处理/ May refer to the United Nations, the country, place laws and regulations processing第十四部分：运输信息Section 14 Transport Information危险货物编号/ Hazardous goods serial number：6205-12-6运输专用名称/IATA Proper Shipping Name：非危险品/ Non-dangerous material危险等级/ Dange

30、rous rank：/包装等级/ Packs the rank：2级/2 levels包装方式/ Packs the way：密封镀金桶、玻璃瓶、塑料桶包装/ The seal gold-plating barrel, the glass jar, model the feeding trough packing运输注意事项/Transportation matters needing attention：密封储存于阴凉、干燥通风处，防潮、防水、远离火种和热源/ The seal storage in cool, ventilates dry place, moisture-proof, the waterproofing, is far away from the kindling material and the heat source第十五部分：法规信息Section 15 Regulatory Information法规信息/Law Information：危险品运输规章范本/ Technical Instructions for the Sate Transport of Dangerous Goods危险品规则/ Dangerous Goods Regulation