生活污水处理系统用户手册Word文件下载.docx
《生活污水处理系统用户手册Word文件下载.docx》由会员分享,可在线阅读,更多相关《生活污水处理系统用户手册Word文件下载.docx(20页珍藏版)》请在冰豆网上搜索。
ThedetailedtechnologyplandescriptiontotheEquipment8
1.2.1主要机械设备8
TheMainmechanicaldevice8
1.2.2系统工艺流程9
TheCraftprinciple9
1.2.3主体工艺9
Maintechnics9
1.2.4消毒工艺9
Sterilizationtechnology9
1.2.5说明9
Explain9
1.3生活污水处理系统安装、调试、维护、检修说明10
Instructionsforinstallation,operationandmaintenance10
1.3.1操作说明10
Operationinstructions10
1.4常见故障排除11
Remedytocommonfaults11
1.4.1不能正常出水11
Watercannotbedischargedordinarily11
1.4.2接触氧化池曝气不均匀11
Aerationofcontactoxidationtankisuneven.11
1.4.3生物膜挂接效果不明显12
Effectofbiomembranceprocessisnotapparent.12
1.4.4出水水质不达标12
Thequalityofdischargingwaterdoesmeetthestandard12
1.4.5控制出现故障12
Faultsappearincontrol.12
2砂过滤器说明、操作及维护说明12
Mechanicalfilterexplanation,operationandmaintenanceinstruction12
2.1设备说明12
EquipmentDescription12
2.2设备技术参数13
Equipmenttechnicalparameters13
2.3技术标准14
Thetechnicalstandard14
2.4Equipmentoperatinginstructions15
设备操作说明15
3、回转式格栅除污机设备说明及操作、维护说明15
TheDescriptionofRotaryBarScreenTrash-removalDevice15
3.1概述15
General15
3.2工作原理16
Principleofwork16
3.3特点与使用条件17
TheCharacteristicandtheusingconditions17
3.4主要技术参数17
Themaintechnicalparameters18
3.5供货范围18
Scopeofsupply18
3.6各部说明19
Explanationforeachparts19
3.6.1驱动装置19
Driveunit19
3.6.2机架20
Frame20
3.6.3耙栅装置20
Thescreenrake20
3.6.4导向装置21
Theguidegear21
3.6.5水底拦栅21
Thesubmarinefence21
3.6.6电气控制柜21
Theelectricalcontrol21
3.7安装技术条件22
MountingTechnologySpecifications22
3.8现场检验和调试23
Checkinganddebuggingonsite23
1生活污水处理系统说明
Technicaldescriptionsforequipments
1.1设备描述
Equipmentdescription
★设备由缺氧池、生物接触氧化池、沉淀池、污泥池、消毒池等部分组成。
Theequipmentismadeupoftheanoxicationtank、thebiologicalcontactoxidationtank、thesedimentationtank、thesludgetank、thedisinfectiontankandsoon。
★缺氧池是生活污水处理的第一段,采用厌氧的生化处理工艺。
生活污水经管道收集后首先提升进入缺氧池,本部分的主要作用是降解难于处理的大分子有机物,降低后续处理设施的负荷,为提高出水水质提供保证。
内挂生物填料。
该填料使用寿命长,挂膜、脱膜容易,使污水处在处理最佳状态,有利于生物降解。
Theanoxicationtankisthefirststepofthesanitarytreatment,usingtheanoxicationbiochemistrytreatment.Aftercollectedbythepipes,thesanitarysewageispromotedtotheanoxicationtank.Themainfunctionofthispartistobreakdownthemacro-moleculeorganicmattersthataredifficulttotreat,toreducetheloadingofthefollowingprocessandprovidetheguaranteetoenhancethewaterleakagewaterquality.Thebiologicalpaddingishangedinside.Thispaddinghaslongservicelifeandeasytohanganddoffthemembrane.Itmakesthesewagestayinthebesttreatingconditionanddogoodtothebiodegradation.
★缺氧池出水自流进入生物接触氧化池。
生物接触氧化池为好氧处理工艺,具有较高的处理效率。
内挂生物填料,采用微孔曝气。
Thewaterleakfromtheanoxicationtanktothebiologicalcontactoxidationtank.Thebiologicalcontactoxidationtankisthefor-oxygentreatmentcraft.Ithashightreatefficiency.Itisthecorepartofthesanitarysewagetreatment.Themovementeffectdecidedirectlythetreatment’squality.Thechoiceofthedesignparameterdecidedirectlythewaterleadagethatthefacilitycanachieve.Thebiologicalpaddingishangedinside.Usetheporeaeration.
★生物接触氧化池出水自流进入沉淀池。
经过厌氧、好氧生化处理的生活污水,在沉淀池内沉淀净化,具有良好沉淀性能的杂质在沉淀池内沉淀下来,出水水质明显提高,上部清水进行消毒处理。
Theleakageofthewaterflowsfromthebiologicalcontactoxidationtanktothesedimentationtank.Afteranti-oxygenandfor-oxygenbiochemistrytreatment,thesanitarysewageisdepositedandpurifiedinthedepositingtank.Theleakagewater’squalityisimproved,usetheclearwatertosterilize.
★沉淀池出水自流进入消毒池。
生化处理后生活污水在消毒池内进行消毒处理,消毒形式为投加固体氯片溶解消毒。
经过消毒可以有效杀死各种致病菌类,保证出水细菌学指标满足相应标准。
Theleakageofthewaterflowsfromthesedimentationtanktothedisinfection.Afterbiochemistrytreatmentthesanitarysewageissterilizedinthedisinfectiontank.Themethodistotrowthesolidchlorinepiecetodissolveandsterilize.Disinfectioncaneffectivelykillmanykindsofpathogenesisfungusandguaranteethebacteriumtargetofthewatertosatisfythecorrestankingstandard.,Thispartincludethemainprincipalitemsasfollows:
★沉淀池产生的污泥部分回流进入生物接触氧化池,保持生物菌群的数量和活性,部分排入污泥浓缩池,污泥浓缩池上清液回流至进水调节池,继续处理。
浓缩池内的污泥定期外排。
Partofthesludgeproducedinthesedimentationtankrefluxintothebiologicalcontactoxidationtank,maintainthequantityandactivenessofthebiologybacteriacolony.Anotherpartaredispersedintothesludgethickeningtank.Theclearliquidinthesludgethickeningtankrefluxintothewateradjustmenttankandcontinuetotreat.Thesludgeintheconcentrationshallbedischargedregularly.
★氧化风机Theoxidizedairblower
生活污水处理设备配备氧化风机4台,用于生物接触氧化池的供氧.
Thesanitarysewagetreatequipmentisequippedwithfouroxidizedairblowers,supplyingoxygentothebiologicalcontactoxidationtank。
型号(Type)HC-50IS
制造商:
江苏百事德
Manufacturer:
JiangsuB-TOHIN
并满足以下要求:
Andsatisfythefollowingtechnicalrequirement:
风机主机、止回阀、安全阀为品牌优质产品。
所供风机安全、平稳、可靠,噪声符合设计要求。
风机加工符合国家相关标准。
风机性能满足原设计及技术要求,并保证运行安全可靠,密封性能良好。
所供风机保证可使用国产机油作为齿轮机油。
所配绕性接头具备相应的耐压能力及一定的耐温能力。
Theairblower’smainengine,thecheckvalveandthesafetyvalvearethebrandqualityproduct.
Thesuppliedairblowermustbesafe,steadyandreliable.Thenoisemeetsthedesignrequirement.
Theairblower’sprocessingmeetstherelatednationalstandard.
Theairblower’sperformancemeetstheoriginaldesignrequirementandguaranteethemovementissafetyandreliable,thesealingpropertyisgood.
Thesuppliedairblowercanusethedomesticallyproducedmachineoilasthegearoil.
Thesuppliedcirclingjointshouldhavethecorrestankingpressure
Resistanceabilityandacertainheatresistantability.
★回用水泵
reusepump
生活污水处理设备配套回用水泵2台,用于排放消毒处理后的生活污水,参数为:
Thesanitarysewagetreatequipmentisequippedwithtworeusepump.Theyareusedtodischargethesanitarysewageafterdisinfection.Thepreliminarydefinitedparameteris
型号Type:
50WQ/6241-2.2-Z
制造商:
上海凯泉
Shanghaikaiquan
★污水升压泵Thesewagepump
生活污水处理设备配套生活污水升压泵4台,用于提升生活污水,参数为:
Thesanitarysewagetreatequipmentisequippedwithfoursewagepump.Theyareusedtolifethesanitarysewage.Thepreliminarydefinitedparameteris:
50WQ/6240-1.1-Z
★中间水泵Themid-waterpump
生活污水处理设备配套生活中间水泵4台,用于砂过滤器提升,参数为:
Thesanitarysewagetreatequipmentisequippedwithfourmid-waterpump.Theyareusedtolifethesandyfilter.Thepreliminarydefinitedparameteris:
★反洗水泵Thebackwashingpump
生活污水处理设备配套生活反洗水泵4台,用于砂过滤器反洗,参数为:
Thesanitarysewagetreatequipmentisequippedwithfourmid-waterpump.TheyareUsedforsandfilterbackwashing.Thepreliminarydefinitedparameteris:
并满足以下技术要求;
泵安装在便于运行和检修的位置。
泵设计为在压头和容量上具有合理裕度以补偿预计磨损的任何正常磨损速度。
保证这类过度容量不会增加达到腐蚀水平的相关系统内的速度。
除非在相应泵的相关条款中另行规定,泵在容量和压头上分别有最小10%和20%的富裕量。
所供水泵安全、平稳、可靠、噪声符合设计要求。
水泵的涂漆及质量应合机电部标准,没有脱漆、凹坑、鼓包、硬器刮痕等外部损伤。
水泵加工符合国家相关标准及相应厂标。
水泵性能满足设计及使用要求,并保证运行安全可靠,密封性能好,自动系统可靠,空载盘车灵活自如,叶轮无卡涩、无异声。
所供水泵在工作时考虑并联运行的可能,保证各泵在并联运行时,扬程统一,流量不变。
每台水泵出厂前作好水泵的技术性能特性曲线,并提交给需方。
Andsatisfythefollowingtechnicalrequirement;
Thepumpsareinstalledinthepositionthatisconvenienttorunandoverhaul.
Thepumpsaredesignedtohavethereasonableallowanceinthedischargeheadandthecapacitytocompensateanypredictednormalabrasionspeed.Guaranteethissurpluscapacitycan’tincreasetoreachthecorrosionlevelspeedinthesystem-relatedspeed.
Ifstipulatedincorrestankingitem,thepumpsmusthavethesmallest10and20%richallowanceseparatelyonthecapacityandthedischargehead.
Thesuppliedpumpmustbesafety,steadyandreliable.Thenoisedesignmustconformtherequirement.
Thepumpspaintingandqualitymustcorrestankthenationalmachineelectricaldepartmentstandard,theexteriordamagesuchas.Escapingthepaint,thepit,thesalient,thehardscratchesarenotpermitted.
Thepump’sprocessingmustmeetthenationalrelatedstandardandthecorrestankingfactorystandard.
Thepump’sperformancemustmeetthedesignandoperationrequirements.Guaranteetherunningissafetyandreliable,thesealingpropertyisgood,theautomaticssystemisreliable,thefreejiggerisfree.Theimpellerdoesn’thavebayonetsandstrangesounds.
Whilerunning,thesuppliedpumpsmustconsiderthepossibilityofparalloperation.Thefactoryguaranteeallthepumpshavethesameliftlevelandthecurrentcapacityisinvariablewhenparalleling.
Beforeleavingthefactory,eachpumpmustfinishthewaterpump’stechnicalperformancecharacteristiccurveandsubmitittotheconsumer.
1.2设备详细技术方案描述
ThedetailedtechnologyplandescriptiontotheEquipment
1.2.1主要机械设备
TheMainmechanicaldevice
包括缺氧池、生物接触氧化池、沉淀池、消毒池、污泥池、氧化风机(4台)、回用水泵(2台),污水升压泵(4台),中间水泵(4台),反洗水泵(4台),曝气系统2套、生物填料2套,电控系统1套。
Includinganoxicationtank、thebiologicalcontactoxidationtank,thesedimentationtank,thedisinfectiontank,thesludgetank,theoxidizedairblower(4P),reusewaterpump(2P),sewagepump(4P)。
Intermediatepump(4)),reverse-washpump(4)TheAerationsystem2set,thebiologicalpadding1set,theelectricalcontrolsystem2set。
1.2.2系统工艺流程
TheCraftprinciple
本设备采用A/O生化处理工艺,提升泵、缺氧池、生化池、生化处理后再进入沉淀池沉淀后的达标水进入消毒池,污泥一部份回流到氧化池重复利用,剩余污泥由气提装置提升至污泥池。
ThisequipmentusesA/Obiochemistryprocessingcraft.Aftertheliftpump,theanoxicationtank,thebiochemistrytank,biochemistryprocessingthenenterthesedimentationt